An EZGO golf cart goes fast in reverse if the wires on the motor are swapped, the Forward/Reverse switch is not in sync with the direction of the cart, or if there is a short of two wires at the motor or the Forward/Reverse switch. Inspect the cable terminals of the batteries for corrosion. Additionally, we have a nationwide network of warehouses, so shipping is quick and convenient. There are so many intricate golf cart parts that keep your caddie moving. Slowly and surely reinsert the axle shaft and bearing into the seal, - Turn shaft until spline marries with differential side gears, - Reinstate outer snap ring, - Spray WD-40 or equivalent on the outboard spline, - Reinstate brake hub and drum, thrust washer, nut and new cotter pin. EZGO TXT Golf Carts Rear Differential Main Reduction Gear #23501-G03-02. Forward and Reverse Parts. If you get a voltage reading on both the pins, it's defective and must be changed. Not to state the obvious, but it allows the machine to move in the direction you want to move in.
Will NOT fit older model STAR golf carts. Lift Kit and Tire Combos. Check if the reverse switch is making a connection as needed. Free Shipping On Orders Over $150! Navitas Performance Upgrades. Radio Systems and Consoles. You have to just change the switch in this case.
This is a replacement F & R Switch. These contacts might likely have got corroded if the cart was parked in the forward position for a long time. Shop All Accessories. Loose or corroded cable connections or a faulty controller can also cause the golf cart to not move. Tightening or replacing them as required will make the cart move in both directions. A defective Run/Tow or Forward/Reverse switch can also cause a EZGO to not move forward. Rear Axle Installation. Check out for a defective controller and if you notice that it isn't functioning as it should, it's time to get a new one in place of the old controller. Custom Body and Stretch Kits. An EZGO RXV golf cart may not go in reverse due to a faulty reverse microswitch, bad cable connections, a defective solenoid, or a malfunctioning controller. EZGO RXV carts tend to stall if the battery pack voltage is low. Club Car Golf Cart 3-Terminal Micro Switch (Fits 1980-Up). Swap the leads in the 3 o'clock and 9 o'clock positions on the Forward/Reverse switch.
If it fails, replace the controller with a better quality one rather than repairing the old one. Situate a floor jack under the center of the rear axle and jack until enough clearance exists to place jack stands under the axle tubes, - Remove the 'U-bolt' and fittings, - Take off the rear spring shackle assembly and front spring mounting fittings, - Take off the spring. All other fittings should be torqued to 18-22Ft. Get Notified First About Our Latest & Greatest. EZGO Golf Cart Forward and Reverse Switch Assembly Fits 1994 and Up Non DCS. Your EZGO may go in reverse but not forward due to a problem in the F&R contacts, faulty high amperage cables, or swapped motor wires. If they look worn-out, you might consider replacing them rather than trying to set the old ones right. Check if you're able to move the gas cart manually in the reverse direction. EZGO Marathon goes forward but not reverse. Check all the cables and ensure that their connections are firm, tight, and securely in space. For example, suppose you're golf cart shifter handle has worn or simply broken. Why EZGO gas golf cart will not reverse? If they aren't, it's likely that they aren't making contact when the switch is in the reverse position. Check if the brakes are performing as desired and aren't seizing up.
Forward and Reverse Shift Cables. Clean the reverse contacts with a contact cleaner or rub them thoroughly with sandpaper. How to fix an EZGO RXV golf cart that won't go forward or reverse. Sometimes, this happens if the cart is kept in the forward position for a long time. Rear axle installation is reverse order of above. Check if the Run/Tow switch and the Forward/Reverse switch are functioning properly and have not got stuck. A EZGO gas golf cart will not go in reverse if there is a faulty transmission system, improper cable adjustment, a defective microswitch present inside the Forward/Reverse controller, or a malfunctioning neutral limit switch. EZGO Golf Cart High-Output F&R Switch (Fits 1994-Up). 2 Terminal Golf Cart Microswitch 1014808. Look out for a closed pedal switch that could be restricting the movement of the golf cart. Dashes and Accessories. You can do this by hooking the wires present under the dash, connecting it to the battery, an ohmmeter, and check the reading. Although this problem is found more often in electric carts, they can at times cause an issue in gas carts as well.